Choosing an ATV or Recovery Winch by Esther Pearson

When it comes to accessories for your off road vehicle, a winch is one of the most important accessories you can buy. If you're a hardcore off roader, no doubt you're going to find yourself in a few sticky situations. An ATV or recovery winch can get you out and back on the trail in no time, so you can spend less time stuck in the mud and more time playing.

The number of options available for your first off road winch can be overwhelming, especially if you don't understand the pros and cons of each feature. You want to make sure you get the right winch for your vehicle, or you could end up just as stuck as before. If you're a first-time buyer, there are four basic design options to consider:

1. Rated Line Pull
2. Line Speed
3. Cable Type
4. Solenoid Mounting

The first factor you'll need to consider is rated line pull. If you buy a winch that's too small for your vehicle, you'll have a tough time getting unstuck. If you buy one that's too big, you're going to add excess weight to your front or rear bumper, which can throw your vehicle off balance as well as slow you down.

The rated line pull is the maximum amount of force that your winch can handle. You can calculate the minimum rated line pull by multiplying your gross vehicle weight by 1.5 (GVW x 1.5 = minimum rated line pull). Notice that this is only the minimum rating you'll need. Depending on how you use your winch, you may need a higher line pull. For example, if you're a mud hole addict, keep in mind that the suction force of the mud requires a greater pulling force to get you out.

The second consideration is line speed. How fast do you want to winch out? Line speed depends on the gear train in your winch. The two basic types are planetary and worm. Planetary includes multiple gears for a faster pull; however, it also generates a greater amount of heat. Worm uses only two gears, which makes for a slower pull but less heat.

Third, you'll need to decide between steel and synthetic cable. Both types of cable have their advantages and disadvantages. Steel winch cable requires less maintenance and can withstand a greater amount of heat. On the downside, burrs from the steel can gash your skin if you're not careful, and a steel cable creates a dangerous whiplash effect if snapped under load.

Synthetic winch rope is lighter, safer, and stronger but requires more care and attention and can weaken if rubbed over sharp objects during the recovery process. The type of cable you choose depends on a number of factors, including the terrain you cover and the weight you're willing to add to your vehicle.

The last consideration is how the solenoid, also known as a contactor, is mounted. Integrated or remote are your two options. Integrated solenoids are built into the winch itself and provide greater protection; however, the added space they take up may require you to modify your vehicle if your mounting space is restricted. Remote solenoids mount separately, offering greater versatility. The remote option is more popular because it allows you to install the winch in a tight space and mount the contactor elsewhere.

Perhaps the best part of any off road winch is the freedom it gives you to ride harder. So with your vehicle ready for the worst nature can dish out, you're free to dig for the bottom of that mud hole or conquer the mother of all boulders without the fear that you'll be stuck there forever. With a quality ATV or recovery winch, your vehicle is ready for bigger and better off road adventures.

About The Author

Copyright 2009 Gorilla Winches. Ready to find your new ATV or recovery winch? Check out Gorilla Winches at http://www.gorillawinches.com. Free shipping on all products! Learn more about choosing a winch at the Gorilla Blog at http://www.gorillawinches.com/blog.

Reprint Rights: Feel free to reprint this article, provided that the article is published in its entirety as written and includes the copyright section, author bio, and active URL links.